发电机组水箱是燃气发电机组的散热装置，起到很好的散热作用。平时，我们应该特别注意水箱的使用。在给发电机组水箱加水的过程中，要注意不要用井水和地下水做纯净水。发电机组水箱网介绍水箱的两种保养方法：

The water tank of generator set is the heat dissipation device of gas generator set, which plays a good role in heat dissipation. At ordinary times, we should pay special attention to the use of water tanks. In the process of adding water to the water tank of the generator set, pay attention not to use well water and groundwater as pure water. The water tank network of the generator set introduces two maintenance methods of the water tank:

用热水喷（加清洁剂）：方法是从散热器前面向风扇的方向喷（比如反方向喷只会把脏东西压到位置）。使用此方法时，用胶带盖住柴油发电机，如果顽固的沉积物无法清除，则应将散热器拆下，在热碱性水中浸泡20分钟左右，然后用热水清洗。

Spray with hot water (add detergent): the method is to spray from the front of the radiator to the direction of the fan (for example, spraying in the opposite direction will only press the dirt to the center). When using this method, cover the diesel generator with adhesive tape. If the stubborn sediment cannot be removed, remove the radiator, soak it in hot alkaline water for about 20 minutes, and then wash it with hot water.

内部除垢：将散热器中的水排干，然后将散热器与管道连接的地方开封，如果仍有水渍，用8%的酸溶液再次清洗，除垢后使用3%的酸溶液。用碱性溶液中和2次，再用清水冲洗3次以上。全部工作完成后，检查散热器是否漏水。如果泄漏，请申请外部维修。如果没有泄漏，请重新安装。加满水并添加防锈剂。

Internal descaling: drain the water in the radiator, and then open the place where the radiator is connected with the pipe. If there is still water stain, clean it again with 8% acid solution, and use 3% acid solution after descaling. Neutralize with alkaline solution for 2 times, and then rinse with clean water for more than 3 times. After all the work is completed, check whether the radiator leaks. In case of leakage, please apply for external repair. If there is no leakage, please reinstall. Fill up with water and add rust inhibitor.

发电机组的水箱是水冷发动机的重要组成部分。作为水冷式发动机冷却回路的重要组成部分，它可以吸收气缸体的热量，防止发动机过热。由于水的比热容大，吸收缸体热量后的温升不大，所以发动机的热量通过冷却水的液路，以水为热载体传导热量，然后通过大面积散热片进行对流。散热方式，以保持发电机组的适当工作温度。

The water tank of generator set is an important part of water-cooled engine. As an important part of the cooling circuit of water-cooled engine, it can absorb the heat of the cylinder block and prevent the engine from overheating. Due to the large specific heat capacity of water, the temperature rise after absorbing the heat of the cylinder block is not large, so the heat of the engine passes through the liquid path of cooling water, uses water as the heat carrier to conduct heat, and then convection is carried out through large-area fins. Heat dissipation mode to maintain the proper working temperature of the generator set.

当发电机水温较高时，水泵的水反复循环，以降低发动机的温度（水箱由中空钢管组成。高温水进入水箱循环至空冷后的发电机汽缸壁）。发动机的目的，如果冬天水温过低，此时会停止水循环，防止柴油发电机组的发动机温度过低。发电机组的水箱在整个发电机组本体中起着非常重要的作用。如果水箱使用不当，会对发电机造成损坏，严重的甚至会导致发电机报废。

When the water temperature of the generator is high, the water of the water pump circulates repeatedly to reduce the temperature of the engine (the water tank is composed of hollow steel pipes. The high-temperature water enters the water tank and circulates to the generator cylinder wall after air cooling). The purpose of the engine is to stop the water circulation if the water temperature is too low in winter, so as to prevent the engine temperature of the diesel generator set from being too low. The water tank of the generator set plays a very important role in the whole generator set. If the water tank is used improperly, it will damage the generator, and even cause the generator to be scrapped.

关于发电机组水箱的维护保养内容就讲解到这里了，任何一个设备如果不好好维护保养也会面临很快会使用出问题的，因此以上希望能够给您帮助，更多内容就来网站//www.gz-yanye.com咨询吧。

That's all for the maintenance of the water tank of the generator set. If any equipment is not well maintained, it will soon have problems in use. Therefore, I hope the above can help you. For more information, please visit the website //www.gz-yanye.com Consult.