不论高浓度和低浓度的燃气发电机组，由于特殊性就要注意发电机组的检测和维护，此外瓦斯发电机组的维护应灵活控制启动时间，下面来讲解下维修检查工作怎么做。

Regardless of the high concentration and low concentration of gas generator units, due to the particularity of natural gas, attention should be paid to the detection and maintenance of generator units. In addition, the maintenance of gas generator units should flexibly control the starting time. Here is how to do the maintenance and inspection.

瓦斯发电机组A类维修检查

Class A maintenance and inspection of gas generator set

检查发电机组的日常工作报告，并根据日常工作报告安排维护和必要的调整。

Check the daily work report of the generator set, and arrange maintenance and necessary adjustment according to the daily work report.

检查发电机组的平面和冷却液液位，主要是区分油尺的高度标记和位置标记。冷却后，须检查冷却平面。

Check the plane and coolant level of the generator set, mainly to distinguish the height mark and position mark of the oil dipstick. After cooling, check the cooling surface.

检查发电机组是否损坏，皮带是否松动或磨损。如果皮带松动或打滑，应及时进行调整或更换。

Check whether the generator set is damaged and whether the belt is loose or worn. If the belt is loose or slipping, it shall be adjusted or replaced in time.

机组正常启动后，检查机油压力是否正常，功率是否充足，冷却水和机油温度是否正常以及燃料，冷却剂和润滑油是否泄漏。

After the unit starts normally, check whether the oil pressure is normal, whether the power is sufficient, whether the temperature of cooling water and oil is normal, and whether the fuel, coolant and lubricating oil leak.

瓦斯发电机组B级检修

Level B maintenance of gas generator set

更换发电机组的机油。更换时间为250小时或1个月。换油标准不得超过油尺上的高标记。

Change the engine oil of the generator set. The replacement time is 250 hours or 1 month. The oil change standard shall not exceed the high mark on the oil dipstick.

更换发电机组的机油滤清器。在安装新的机油滤清器之前，好在密封件上涂抹一层机油。请勿过度拧紧机油滤清器，否则会导致机油泄漏。

Replace the oil filter of the generator set. Before installing a new oil filter, coat the seal with oil. Do not overtighten the oil filter, or oil leakage may occur.

更换机油滤清器滤芯。更换滤芯时，须排出发电机组中的空气。

Replace the oil filter element. When replacing the filter element, the air in the generator set must be exhausted.

发电机组的空气过滤器进行清洁或更换。

Clean or replace the air filter of the generator set.

以上是瓦斯发电机组维修检查分A、B类这一问题的相关解答内容了，您对此有什么不理解的地方可以随时来我们网站//www.gz-yanye.com留言咨询。

The above is the answer to the question of gas generator unit maintenance and inspection divided into A and B categories. If you have any questions about this, you can come to our website at any time //www.gz-yanye.com Leave a message for consultation.